Lanier Worldwide, Inc.
2300 Parklake Drive, NE
Atlanta, GA USA 30345-2979
MATERIAL SAFETY DATA SHEET
Emergency Telephone: 800-551-3087
Section 1: Chemical Product and Company Information
Identity:
Product ID:
MSDS No.
Black Toner Cassette Type Q1
CP- 430
480-0239
Issued: 12/23/2004
Supersedes:
none
12/23/2004
EH&S Department 770-496-9500
Synonyms
& Common
Names:
Date:
Toner Black Cassette Type Q1
Lanier LC031c
Prepared by:
Approved by: Larry Choskey, Manager, CEH&S
Walter Fricke, Manager, Safety &
Environment,
Lanier Worldwide, Inc.
Im Taubental D-41468 Neuss,
Germany +49-2131-387-177
European
Contact:
Uses:
Chemical
Formula:
Mixture
Section 2: Composition / Information on Ingredients
PERCENT
75 – 85
< 10
CAS No.
Confidential
1333-86-4
EXPOSURE LIMITS
SOURCE
N/a
OSHA PEL
ACGIH TWA
N/a
N/a
OSHA PEL
ACGIH TWA
Polyester resin
Carbon black
Not listed
3.5 mg/m3
3.5 mg/m3
Not listed
Wax
Silica
Zinc sterate
< 10
<5
< 2
Confidential
68909-20-6
557-05-1
Not listed
15 mg/m3
10 mg/m3
*PEL as the product: 15mg/m3 (total dust), 5mg/m3 (respirable dust)
*TLV as the product: 10mg/m3 (total dust), 5mg/m3 (respirable dust)
Section 3: Hazards Identification
HMIS Rating:
FLAMMABILITY = 1
REACTIVITY = 0
HEALTH = 1
SPECIAL = none
Health Hazards (Acute, Chronic, Immediate and Potential):
Acute Eye Effects: Non-irritant
Acute Skin Effects: Non-irritant, non-sensitizer
Acute Inhalation Effects: Excessive inhalation may cause irritation of the nose, throat and respiratory tract.
Acute Ingestion Effects: None currently known.
Primary Entry Routes: Inhalation, dermal contact, incidental ingestion.
Health Hazards of Long Term exposure (Chronic): Prolonged inhalation of excessive dust may cause lung damage. It is
attributed to “lung overloading”, a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval.
Use of this product, as intended, does not result in inhalation of excessive dust.
Carcinogenicity: Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation
study in rats. However, there was not observed the incidence of tumors on the test results on dermal or oral studies. Also, 2-years
inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors.
Medical Condition Aggravated By Long Term Exposure: Respiratory disorders, such as asthma, may be aggravated by
prolonged exposure to high concentrations of this product.
Miscellaneous: Prolonged exposure to dusts of this product may irritate the respiratory system.
Section 4: First Aid Measures
Remove to fresh air immediately. Get medical
In case of contact, immediately flush eyes
with water for 15 minutes. Get medical
attention if needed.
Dilute stomach contents with several
glasses of water. Get medical attention.
attention if needed.
Inhalation:
Eye Contact:
Ingestion:
Wash with soap and water. Wash clothing before
reuse. If irritation occurs or is persistent, seek
medical attention.
Skin Contact:
your document management partner
MATERIAL SAFETY DATA SHEET
Section 13: Disposal Consideration
Page 3 of
3
CP-430
Used toner should be disposed of under conditions that meet all federal, state and local environmental regulations. Disposal
regulations vary from locality to locality; therefore consult your local Lanier office or the EPA to determine the proper method for
disposal. Do not incinerate loose or spilled toner
Section 14: Transportation Information
International regulations:
RID/ADR
DOT 49 CFR
ADNR
Not applicable
Not applicable
Not applicable
ICAO-TI/ATA-DGR
UN Classification Number
IMDG Code
Not applicable
Not applicable
Not applicable
Specific precautionary transport measures: Avoid direct sunlight. Do not keep over 35°C (95°F).
Product label: Black Toner Cassette Type Q1
Section 15: Regulatory Information
Regulation:
Canadian Disclosure List: Zinc sterate: (557-05-1)
TSCA (Toxic Substances Control Act): All chemical substances in this product comply with all applicable rules or orders under
TSCA.
RCRA (40 CFR 261): Product or components not listed.
CERCLA/SARA: Not regulated.
California Proposition 65: neither toner, nor any of its components are listed as chemicals known to cause cancer or
reproductive system effects.
Controlled Products Regulations (Canada): This product has been classified in accordance with the hazard criteria of the CPR.
Workplace Hazardous Materials Information System (Canada): No toxicology information is available.
Other State Regulations: Carbon Black is listed in the New Jersey Right to Know List, Pennsylvania Hazardous Substances List,
and the Massachusetts Substance List.
US/Canada Label Statements: Low hazard for recommended handling: Minimize dust generation and accumulation. Use with
adequate ventilation.
Section 16: Miscellaneous Information
Judgment as to the suitability of information contained herein for user’s purposes is the responsibility of the purchaser.
Therefore, although reasonable care has been taken in the preparation of this information, Lanier Worldwide, Inc. extends no
warranties, makes no representations, and assumes no responsibility as to the accuracy or suitability of such information for
application to user’s intended purposes or for consequences of its use. All materials may present unknown hazards and
should be used with caution. Although certain hazards are described herein, we do not guarantee that these are the only
hazards that exist.
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under
normal conditions. On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the
usual precautionary measures for dealing with chemicals.
|